广西顶博发电机组制造

13667715899

添加微信好友了解产品w13667715899

当前位置:首页 > 技术支持

又到暴雨潮湿季节了,广西顶博发电机组制造进水该怎么办?

2021-07-31
来源: 原创
106296
当多雨或强风季来按规定,有有可能会经受洪水洪涝、大暴雨等大自然洪涝的危害,因汽油启倾向风能发调速电启动冷库超临界锅炉BGP机房一般来说是在地下水室或许1楼会被水淹,如风能发调速电启动冷库超临界锅炉储存防护衣疏于或许其他的原由水有有可能会从烟管开启启倾向缸体。当汽油启倾向风能发调速电启动冷库超临界锅炉存水时,若在暖机请立马宕机,并实行这个必要的机制,重连外供电及蓄电板接驳线,的同时进行检查各种布位的存水环境。


When the rainy season or typhoon season comes, it may be affected by natural disasters such as flood and rainstorm. Because the diesel generator set room is generally in the basement or the first floor, it is easy to be flooded. If the generator set is poorly kept and protected or for other reasons, water may enter the engine cylinder from the smoke pipe. When water enters the diesel generator set, if it is running, please shut down immediately, take necessary measures, disconnect the external power supply and battery connection line, and check the water inflow at all parts at the same time.


广西顶博发电机组制造机房


检查广西顶博发电机组制造进水常见问题

1、查看泄压阀压缩空气管道(排风管管比较低处或消音器器)的排污混凝土构件是否是有冰排尽。Check the exhaust pipe to see if there is water discharged from the drainage component.


2、检验气空气滤网设备壳有没有需要有排水,滤网有没有需要被水浸渍。Check whether there is water in the air filter housing and whether the filter element is immersed in water.


3、审核发高压电机组机壳体边侧是否能够有雨水。Check whether there is water accumulated at the bottom of the generator casing.


4、诊断热管冷却器、电扇、轴承等换向部分是不是也梗塞。Check radiator, fan, coupling for blockage.


5、静态会不设计油、燃料或水的渗漏。Whether there is leakage of organic oil, fuel or water from the outside.


6、卸掉拐臂室盖,分析是否是有入水。诊断生产发马达线圈绝缘带/废弃物实际情况。Remove the rocker chamber cover and observe whether there is water ingress. Check the insulation and ontamination of the generator windings.


7、检验掌握新线路和输出电压电路系统的隔绝。检验掌握表面板传感器、各电子仪表、告警安装、运行控制开关。Check the insulation between the control circuit and the output circuit. Check the control panel module, each instrument, alarm device and start switch.


小心:肯定难以让水侵袭打火机的进行汽缸!Note: Never let water enter the combustion chamber of the engine!


漏液清理技巧汽油来发无刷电热泵机组进行进水后的加工处理无法:Treatment  after water enter the generator:


当答案重油电站设备打着机的烧燃室没能漏电,绝缘层具有规范要求时,可开机重油电站设备。在开机时要重视以下的相关问题:When confirm there is no water in the combustion chamber  and the insulation meets the requirements,can start the generator. Pay attention to the following issues when starting:


1、在发动往前走行那些查检,包扩尾气排放汽油箱雨水。机电系统的一步一步上电,关注是否有有超时。Do all inspections before starting, including draining water in the fuel tank. The electrical system is gradually powered on, and observe whether there is any abnormality.


2、多次再开启打着机的时段不了达到十秒钟。若打着机没能失火,则检修汽油滤油器及电力工程电路开关,两三15分钟后其次再开启。Start the engine continuously shall not exceed 30 seconds. If the engine cannot catch fire, check the fuel line and electrical circuit, and start again after one or two minutes.


3、查检汽车发思想的声音要不要有有发现异常,要不要有有怪味。查检组合件仪器的展现、液晶板展现屏要不要有断屏并且展现不清。


Check whether the engine sound is abnormal and whether there is a peculiar smell. Check whether the display of the electrical instrument and the LCD screen are broken or unclear.


4、融洽留意打着液压油重压和水环境温暖,如果你汽压或环境温暖不复合合技术应用标准规范,应关了打着机。宕机后,捡查连续打着液压油平米。Closely observe the oil pressure and water temperature. If the oil pressure or temperature does not meet the technical specifications, the engine should be shut down. After stopping, check the oil level.


当评判汽车发行为可能性接触不良、火力发直流三相电机接地对不上合想要时,一定要避免私自检修,应追求火力发直流三相电超临界锅炉厂的职业 水平师的帮忙。When it is judged that water may enter the engine and the insulation of the generator does not meet the requirements, do not repair it without authorization, and seek the help of professional technicians from the generator manufacturer.


雷暴/天气潮湿生态环境,静音电站设备应用特别注意重点难点Key points for unit operation in rainstorm / humid environment


1、放入工作环境必须1. Placement environment requirements(1)野外摆放选用的发电机组,需最好防水控制措施,运行环境防水棚、靜音箱等;


Rainproof measures shall be taken for units placed outdoors, and rainproof sheds, static speakers, etc. shall be equipped;


(2)冷库机组壳体须有可信的保护性跨接,对要求有比较适中点可以直接跨接的发电站机,则需要由正规专业者实现比较适中跨接;The shell of the unit must be reliably grounded. For generators requiring direct neutral grounding, the neutral grounding must be carried out by professionals;


(3)雷击多发病的地方用到广州POS机,请分配防雷配置。If machines are used in lightning prone areas, please configure lightning protection devices.


(4)请千万不要将冷库机组搭建于地型较低,基础不牢(沙子路面)会污水的特点;Please do not place the unit in a place with low terrain, weak foundation (soil ground) and easy to accumulate water;


(5)放上在地上室选择的仪器,需准备好地上室排水管、地下室防潮作业。For machines placed in the basement, drainage and moisture-proof work in the basement shall be done well.
报价:13667715899
引荐好的文章
柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家